79cc Lifan Engine Mods?

tillotson fuel injection carb will fit your phatmoto 212 predator and make more power... 40$
Tillotson TCT Mechanical Fuel Injection - GoPowerSports.com
https://www.gopowersports.com/tillotson-tct-mechanical-fuel-injection/
Rating: 5 - ‎4 votes - ‎$39.95 - ‎In stock
GO FAST WITH TILLOTSON TCT MECHANICAL FUEL INJECTION. This is a direct replacement for your Predator 212cc or any Honda 6.5hp clone carburetor


i only found out about this the other day myself.

there was talk of other sizes circa 2016 but no more details still.

looking into them...whilst they start easy and give good low speed performance (no bogging etc) they lack in the high end due to small venturi sizes.

ie, expect more power at low speeds, but dont expect an increase in top speed. the exact opposite actually.

still for $40 (more like AU$140 after the exchange rate and shipping...) it could be worth a try...i wanna see how one deals with turbocharging...
 
Great info,thank you! I already welded up a straight pipe,and had no power/speed increase from it. I’ll try a 22mm carb like you suggested. Maybe that and the pipe together will give me a tad more. I’d love to see a 212cc predator engine on one of these Phatmoto bikes instead of that 79cc Lifan engine. I just want to see somebody do it first so I have something to follow along to.
Is the predator 212cc engine base the same size as the original Rover engine
 
Drain the engine oil and remove the side case gently so you don’t ruin the gasket. I lightly tapped my side case with a rubber mallet and the gasket stayed in tact. Then you have to cut out the plastic governor that you’ll see in the engine. I then used a dremel tool,hammer,and screwdriver to get the gear out of there. Be sure to remove all the debris when your done.
 
sadly no. there are no aftermarket parts aside from carb, intake, exhaust. you're in the same boat as Predators and other clones in that size but the good news is you can definately supe it up yourself with a little work. Some Honda valve train parts can fit or engine made to accept in the way of valves, springs & rockers. I'd start with looking at GX100 parts and try to get measurements/specs on them before buying. At the point you'd spend $200 on engine upgrades you'd probably be farther ahead to go with a bigger engine or downsize to a high revving 49cc which is lighter and actually has a higher top speed than a 79
Can u send link for exhaust and carb intake ?
 
mechanical fuel injection carb will fit it ... i did one on my bike
Tillotson TCT Mechanical Fuel Injection - GoPowerSports.com
https://www.gopowersports.com/tillotson-tct-mechanical-fuel-injection/
Rating: 5 - ‎4 votes - ‎$39.95 - ‎In stock
GO FAST WITH TILLOTSON TCT MECHANICAL FUEL INJECTION. This is a direct replacement for your Predator 212cc or any Honda 6.5hp clone carburetor.
You've visited this page 4 times. Last visit: 7/11/19

TCT Archives - Tillotson
https://tillotson.ie › Shop › Carburetors

Our new TillotsonTCT carburetor is really more than just a carburetor; it's a fully integrated fuel system that combines a form of mechanical fuel injection with ...

How did u do the spring, linkage, bought one tct and installing now
 
low octane fuel unless you want it to die... 98 killed my 142f at least. no issues with 91...


unified head and cylinder?... no chance of raising compression. so again, low octane fuel. better fuel is a waste of money.

single lobe cam operating both valves. so its virtually impossible to change the timing by modding the cam. stiffer valve springs will just wear out the lobe faster and sap power. unless its valve bouncing. which i doubt.

theres nothing off the shelf you can buy. all you can do is try something like a mikuni or oko 22mm carb and an open exhaust... then fiddle...
 
Check out this clean Phatmoto 212 built by Tracy Swann over on the FB Phatmoto (Builds/Mods & Info) Group.

212 engine, Moto rims, full lighting with battery and charging system, bobber seat, and those custom made ape hanger handlebars. WoW! these guys take their Phatmoto mods to the extreme over at https://m.facebook.com/groups/208333067191742


56027106-946E-40DF-9087-248FB6AB1A46.jpeg
 
Back
Top